How To Replace Blend Door Actuator Dodge Caravan

Posted on

Remove the 3 RH temperature blend door actuator screws. Reach in to unscrew the 2 screws in the drawing.

I Removed My 2002 Caravan Blend Door Actuator Motor For Temp Control And When I Rotate The End Of The Door Rod It

Its pretty much the same concept with every vehicle.

How to replace blend door actuator dodge caravan. Perform the Actuator Calibration Test routine found under the Systems Test tab in the HVAC control module view in the wiTECH Diagnostic Application. Safety How YouTube works Test new features Press Copyright Contact us Creators. Heater Blend Door Actuator.

I would pull off the blend door actuator and swap it out with a new one. Remove the RH temperature blend door actuator. Sep 21 2014 Fastest test is to remove the actuator motor and try to turn the shaft of the blend door by hand.

2015 Dodge Grand Caravan AC Heater Blend Door Actuator Shop AutoZone for 2015 Dodge Grand Caravan AC Heater Blend Door Actuator. The part is shown below and costs 32 at autozone. Remove the 3 RH temperature blend door actuator screws.

Disconnect the electrical connector from the blend door actuator being serviced. However if the instrument panel must be removed much deconstruction of the vehicle will take place and the air conditioner may require discharging and recharging before the HVAC system will function properly. The actuator is under drivers side.

Mode Door Actuator – DefrostPanelFloor Door. Heater Blend Door Actuator. Remove the RH lower instrument panel insulator.

Apr 20 2020 Most people with a small tool set can replace the blend door in this situation. Remove the right side instrument panel silencer. Remove the RH lower floor console trim panel.

The system is electronic and the blend door actuator has a specific procedure to calibrate it. The shaft should only be able to make about a quarter of the circle if the shaft is still attached to the door it might catch a bit but if it goes all the way around the shaft is no longer connected to the door. ULTRA-POWER 68031977AA 68033337AA 68238243AA.

Disconnect the RH temperature blend door actuator electrical connector. If the shaft turns all the way around the door needs to be replaced. The actuator is connected to the electrical system via the wire harness you need to open the red locking tab to disengage the connection.

Buy online and pick up in store or get fast free delivery on qualified orders. No parts for vehicles in selected markets. Remove the silencer panel from under the driver s side of the instrument panel.

You may have to remove some panels to get to it. About Press Copyright Contact us Creators Advertise Developers Terms Privacy Policy. Normal diagnosis should be performed.

Remove the glove compartment. 2008-2012 drive side blend door actuator replacementT20 screwdriver – httpsamznto2UaaFfG affiliate linkActuator – httpsamznto2HG30ju affiliate l. Shop AutoZone for 2013 Dodge Grand Caravan AC Heater Blend Door Actuator.

Air Conditioning wDual Zone Temp. Please let me know if you have questions. Follow the sound to the actuator and remove it.

Sep 02 2020 First remove the knee blocker located on the drivers side. Driver side would not change from hot to cold because of a broken gear inside the blend door actuator. Or another option is to swap it out with one of the other actuators.

Install a new one. After unscrewing these 2 screws you can remove the actuator. Did the right side actuator fail the calibration test.

This is an overview video on how to replace a mode door actuator on a 2005 Dodge grand Caravan SXTPART is MOPAR 4885465AA current cost 5500 as of dec 2016. The blend door actuator is interchangeable with the actuators for the mode-air doors and the recirculation-air door. Right Temp Blend Door.

Clicking sound is your blend door actuator stripping its gears and failing to open the door that directs the blower air through the heater core. Location of blend door motors blend door motor testing 08 09 10 11 12 13 14 15 16 17 18 19 Dodge grand Caravan heater control motors heater controller. Remove the ABS control module.

Proceed to step Step 3. Disconnect and isolate the negative battery cable. Disconnect and isolate the negative battery cable.

Manually operate and inspect the RH temperature blend door linkage for incorrect placement binding or damage. Feel the black hvac box and if its feels warm then the heater core is good you will have to remove the dash to replaced the bland door actuator and blend door i reccomend you replace both beacause its alot of work to remove the dash so make sure both components are replaced. Buy online and pick up in store or get fast free delivery on qualified orders.

RH temperature blend door actuator and linkage. Disconnect the glove compartment damper from the glove compartment.

Dodge Journey Blend Door Actuator Removal Replacement Test Fiat Freemont Youtube

Blend Door Actuator Failure A Look Inside Dodge Blend Door Actuator Youtube

I Need To Change The Blend Door Actuator On The Passengers Side 1998 Dodge Grand Caravan

2002 Grand Caravan Blend Door Actuator Youtube

Dodge Caravan Questions Passenger Side Only Blows Heat Cargurus

How To Replace An Automotive Blend Door Actuator

Blend Door Actuator Location I Have 2000 Dodge Grand Caravan

How To Replace An Automotive Blend Door Actuator

2012 Dodge Grand Caravan Passenger Side Actuator Switch F Near New Melle 63365 Mo Bluedodge Com

2008 Dodge Grand Caravan Blend Door Actuator Youtube

Dodge Caravan Questions Passenger Side Only Blows Heat Cargurus

Blend Door Stuck Grand Caravan 2011 Youtube

I Need To Change The Blend Door Actuator On The Passengers Side 1998 Dodge Grand Caravan

Dodge Grand Caravan 2008 Driver S Side Ac Repair Guide Autozone

2003 Dodge Caravan Broken Blend Door Hack Fixed Mine For 2 Bucks Instructables

Dodge Grand Caravan Rear Heater Clicking Front Heat Stuck On Hot Youtube

How To Replace Blend Door Actuator Youtube

5th Gen 08 2013 Rear A C Blend Actuator Repair Dodgeforum Com

How To Replace An Automotive Blend Door Actuator

Read:  Display Driver Nvlddmkm Stopped Responding And Has Successfully Recovered.